沼氣生物脫硫企業商機

　　Business opportunities for biogas biological desulfurization enterprises

　　含有硫化氫(H2S)的沼氣進入脫硫塔底部，在穿過脫硫填料層到達頂端的過程中，含有硫化氫的沼氣首先與底部入口處荷載相對高的脫硫劑反應，反應器上部是負載低的脫硫劑層，通過設計良好的沼氣空速和線速，干式脫硫能到達良好的精脫硫效果。在沼氣進入干式脫硫塔之前，應設置有冷凝水罐或沼氣顆粒過濾器。該裝置可以消除沼氣中夾雜的顆粒雜質，并使得沼氣在進入脫硫前含有一定濕度。當觀察到脫硫劑變色，或系統壓力損失過大時，應交替使用另一個脫硫塔。當前的脫硫塔在沼氣放空后，進行自然通風，對脫硫劑進行再生。當再生效果不佳時，應從塔體底部將廢棄的脫硫劑排除，在底部排放廢棄填料的同時，相同體積的新鮮脫硫填料加入反應器中。在大型的脫硫工程中，一般采用先用濕法進行粗脫硫，之后再通過干法進行精脫硫。乙醇行業沼氣生物脫硫設備

　　Biogas containing hydrogen sulfide (H2S) enters the bottom of the desulfurization tower, and during the process of passing through the desulfurization packing layer to reach the top, the biogas containing hydrogen sulfide first reacts with the desulfurizer with a relatively high load at the bottom inlet. The upper part of the reactor is the desulfurizer layer with a low load. By designing a good biogas space velocity and line velocity, dry desulfurization can achieve good precision desulfurization effect. Before biogas enters the dry desulfurization tower, a condensate tank or biogas particle filter should be installed. This device can eliminate particle impurities in biogas and make biogas contain a certain humidity before entering desulfurization. When discoloration of the desulfurizer or excessive pressure loss in the system is observed, another desulfurization tower should be used alternately. The current desulfurization tower undergoes natural ventilation after biogas is released to regenerate the desulfurizer. When the regeneration effect is poor, the waste desulfurizer should be removed from the bottom of the tower, and fresh desulfurizer of the same volume should be added to the reactor while discharging the waste packing at the bottom. In large-scale desulfurization projects, the wet method is generally used for coarse desulfurization first, and then the dry method is used for fine desulfurization. Ethanol industry biogas biological desulfurization equipment

　　沼氣生物脫硫（簡稱沼氣脫硫）是利用生物菌種去除沼氣中腐蝕性強、毒性強的硫化氫氣體的一種工藝方法，這個工藝具有自動化程度高，流程簡潔，運行成本低等優點。3.工藝原理如下圖，厭氧發酵產生的沼氣進入洗滌塔，通過與堿性循環噴淋液發生吸收反應，從而去除沼氣中的硫化氫。吸收硫化氫的富液回流至生物反應器內，通過生物轉化，將硫化氫轉化成固態單質硫磺，并將溶液再生為可用于洗滌沼氣的堿性吸收液（亦成為貧液），從而實現了吸收劑的回收和再生循環利用。通過硫沉淀器實現硫磺固體的分離。廣東食品行業生物脫硫沼氣生物脫硫工藝都被較廣應用到沼氣、填埋氣、天然氣、水煤氣等工業氣體脫硫工藝中。

　　Biogas desulfurization (abbreviated as biogas desulfurization) is a process method that uses biological bacteria to remove highly corrosive and toxic hydrogen sulfide gas from biogas. This process has the advantages of high automation, simple process, and low operating costs. 3. The process principle is shown in the following figure. The biogas produced by anaerobic fermentation enters the washing tower and undergoes absorption reaction with the alkaline circulating spray liquid, thereby removing hydrogen sulfide from the biogas. The rich solution that absorbs hydrogen sulfide flows back into the bioreactor, and through biotransformation, hydrogen sulfide is converted into solid elemental sulfur, and the solution is regenerated into alkaline absorption solution (also known as lean solution) that can be used to wash biogas, thereby achieving the recovery and recycling of the absorbent. Separation of sulfur solids is achieved through a sulfur precipitant. The biological desulfurization process of biogas in Guangdong's food industry is widely used in industrial gas desulfurization processes such as biogas, landfill gas, natural gas, and water gas.

　　生物脫硫技能技能原理：脫硫技能技能原理其反響的基本原理是將含H2S的沼氣和含有化能自養型微生物的蘇打水溶液進行觸摸，H2S被堿性溶劑吸收后，經微生物催化生成元素硫或硫酸鹽?，F(xiàn)在，技能是全球?qū)Ρ壤暇毜拿摿蚣寄苤?，它具有以下長處：安全：全部生物脫硫系統是關閉運轉的，而且沼氣中的H2S被徹底吸收，在吸收器的沒有游離的H2S，不會有中毒和傷亡事情，無環境污染。節?。涸摷寄芩某鲑Y少，其首要設備和儀器數量少。運轉本錢低，出產所需的操作人員少，減少人力本錢;不需求化學催化劑，生物催化劑不會失活，它自動再生，無須替換，運轉中所需化學藥品少，節省出產本錢;該技能的操作本錢、保護費用均很低。高效：運用該技能確保脫硫后的天然氣中H2S含量小于4ppmv；而且操作彈性大，習慣H2S濃度規模50ppmv～100vol.%，壓力規模1～100barg，具有很高的靈活性，能習慣H2S頂峰負荷。該技能的技能流程簡略，操控系統和監測系統很少，沒有雜亂的操控回路，操作保護簡略便利。適用于對含H2S濃度高的小型氣田，更經濟，效益非常好;而且運用該技能的設備功能穩定，技能牢靠，經濟效益好。

　　The principle of biological desulfurization skills: The basic principle of the reaction of desulfurization skills is to touch biogas containing H2S and soda water solution containing chemoautotrophic microorganisms. After H2S is absorbed by alkaline solvents, it is catalyzed by microorganisms to generate elemental sulfur or sulfate. Nowadays, the skill is one of the most experienced desulfurization skills globally, with the following advantages: safety: all biological desulfurization systems are shut down and the H2S in biogas is completely absorbed, with no free H2S in the absorber, no poisoning or injury, and no environmental pollution. Savings: This skill requires less investment and has fewer primary equipment and instruments. Low operating costs, fewer operators required for production, and reduced labor costs; No need for chemical catalysts, biocatalysts will not be deactivated, they regenerate automatically without replacement, require fewer chemicals during operation, and save production costs; The operating cost and protection cost of this skill are both very low. Efficient: Use this skill to ensure that the H2S content in the desulfurized natural gas is less than 4ppmv; Moreover, it has great operational flexibility and is accustomed to H2S concentration ranging from 50ppmv to 100vol.% and pressure ranging from 1 to 100barg. It has high flexibility and can adapt to the peak load of H2S. The skill process of this skill is simple, with few control and monitoring systems, no cluttered control circuits, and simple and convenient operation protection. Suitable for small gas fields with high H2S concentration, more economical and highly profitable; Moreover, the equipment utilizing this skill has stable functionality, reliable skills, and good economic benefits.

　　沼氣的性：一般可燃?xì)怏w都易與空氣形成混合物，遇到明火就會，造成設備和人身事故。在使用沼氣時，輸送、貯存等沼氣設施要求有較好的密封性及防爆措施。沼氣的毒性：密閉空間中所含甲烷濃度高，使氧氣含量下降，就會使人發生窒息，嚴重者會導致死亡。若空氣中的甲烷含量達到規定的25--30%時就會使人發生、頭暈、惡心、注意力不集中、動作不協調、乏力、四肢發軟等癥狀。若空氣中甲烷含量超過規定的一半以上時就會因嚴重缺氧而出現呼吸困難、心動過速、昏迷以致窒息而死亡。注意事項：沼氣脫硫設備應由專人看管，沼氣管道上的所有閥門必須由專人進行調節。沼氣脫硫設備附近應做到良好通風，以防設備附近沼氣聚積。沼氣脫硫設備附近嚴禁動用明火。沼氣脫硫設備長期停用應將沼氣管上的所有手動閥門關閉。定期檢查沼氣管道上所有閥門的密閉性，防止發生沼氣泄漏事故。一體式脫硫效率高，可達95%～99%，運行成本低，自動化程度高，操作簡便，造價較低。

　　The properties of biogas: Generally, combustible gases are prone to form mixtures with air, which can cause equipment and personal accidents when exposed to open flames. When using biogas, facilities such as transportation and storage require good sealing and explosion-proof measures. Toxicity of biogas: High methane concentration in enclosed spaces can cause a decrease in oxygen content, leading to suffocation and even death in severe cases. If the methane content in the air reaches the prescribed 25-30%, it will cause symptoms such as dizziness, nausea, lack of concentration, uncoordinated movements, fatigue, and limb weakness. If the methane content in the air exceeds half of the prescribed level, severe hypoxia can cause breathing difficulties, tachycardia, coma, suffocation, and death. Attention: The biogas desulfurization equipment should be supervised by a dedicated person, and all valves on the biogas pipeline must be adjusted by a dedicated person. Good ventilation should be maintained near the biogas desulfurization equipment to prevent the accumulation of biogas near the equipment. Open flames are strictly prohibited near biogas desulfurization equipment. If the biogas desulfurization equipment is not in use for a long time, all manual valves on the biogas pipes should be closed. Regularly check the sealing of all valves on the biogas pipeline to prevent biogas leakage accidents. The integrated desulfurization efficiency is high, reaching 95% to 99%, with low operating costs, high degree of automation, easy operation, and low cost.

　　運行過厭氧反應器的工程師都知道，厭氧反應會產生沼氣，而沼氣中往往含有一定量的硫化氫（H2S）。不同的工業廢水，沼氣中硫化氫的含量各有不同。如果硫化氫含量過高，就必須在進鍋爐燃燒之前脫除沼氣中的硫化氫，以避免腐蝕管道和鍋爐。我們就介紹一下當前比較先進的沼氣生物脫硫技術。1.沼氣的來源沼氣通常來源于污水厭氧處理、糞便、秸稈發酵、石油天然氣等，凈化后的沼氣可作為清潔能源，替代天然氣、煤炭，用于發電、取暖、生產蒸汽等；分離出的硫化氫氣體被轉換成固態的生物硫磺，可作為化肥、化工等行業的原料。沼氣經過吸收凈化可資源利用，即實現了節能減排，也節約了企業的生產成本。干法脫硫一般適合用于沼氣量小，硫化氫濃度低的沼氣脫硫。什么是沼氣酸法脫硫特點

　　Engineers who have run anaerobic reactors know that anaerobic reactions produce biogas, which often contains a certain amount of hydrogen sulfide (H2S). The content of hydrogen sulfide in different industrial wastewater and biogas varies. If the hydrogen sulfide content is too high, it must be removed from the biogas before entering the boiler for combustion to avoid corrosion of pipelines and boilers. Let's introduce the currently advanced biogas biological desulfurization technology. 1. The source of biogas usually comes from anaerobic treatment of sewage, manure, straw fermentation, petroleum and natural gas, etc. Purified biogas can be used as a clean energy source, replacing natural gas and coal, for power generation, heating, steam production, etc; The separated hydrogen sulfide gas is converted into solid biological sulfur, which can be used as a raw material for industries such as fertilizers and chemicals. Biogas can be absorbed and purified for resource utilization, which not only achieves energy conservation and emission reduction, but also saves production costs for enterprises. Dry desulfurization is generally suitable for desulfurization of biogas with low methane volume and low hydrogen sulfide concentration. What are the characteristics of biogas acid desulfurization

　　由于硫化氫有毒、腐蝕性強，限制了沼氣的綜合利用。乙醇行業沼氣生物脫硫設備

　　Due to the toxicity and strong corrosiveness of hydrogen sulfide, the comprehensive utilization of biogas is limited. Ethanol industry biogas biological desulfurization equipment

　　生物脫硫的技術優勢，全自動無人值守，高度穩定可靠。深度的硫化氫去除（出口硫化氫含量低于25ppm）可耐受氣體流量和硫負荷較寬范圍的波動，沼氣不會被空氣稀釋：沼氣和空氣之間有嚴格的物理分離，只需少量的堿、水和營養物，沒有堵塞和污垢的風險，因此維護工作量少，常溫常壓運行，產生單質硫：可作為肥料和殺蟲劑，沼氣生物脫硫技術應用的領域非常較多。污水厭氧處理、糞便、秸稈發酵、石油天然氣產生的沼氣硫化氫含量過高，都可以應用。

　　The technological advantages of biological desulfurization include fully automatic unmanned operation, high stability and reliability. Deep hydrogen sulfide removal (with an outlet hydrogen sulfide content below 25ppm) can tolerate a wide range of fluctuations in gas flow rate and sulfur load, and biogas will not be diluted by air. There is strict physical separation between biogas and air, requiring only a small amount of alkali, water, and nutrients, without the risk of blockage and fouling. Therefore, the maintenance workload is low, and it operates at room temperature and pressure, producing elemental sulfur. It can be used as fertilizer and insecticide, and biogas biological desulfurization technology has a wide range of applications. Anaerobic treatment of sewage, fermentation of feces and straw, and high hydrogen sulfide content in biogas produced from petroleum and natural gas can all be applied.

　　本文由  沼氣脫硫設備 友情奉獻.更多有關的知識請點擊  http://www.bjlidejia.com/   真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from biogas desulfurization equipment For more related knowledge, please click http://www.bjlidejia.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.