沼氣脫硫：沼氣廢脫硫劑一般怎么處理？沼氣脫硫劑處理方法

　　Biogas desulfurization: How to treat biogas waste desulfurizer in general? Treatment method of biogas desulfurizer

　　沼氣脫硫劑是一種安裝在沼氣凈化調壓器中脫硫器瓶內的黃褐色顆粒狀物質，它的作用是除去沼氣中的硫化氫氣體，去掉臭雞蛋味，變成真正無污染的節能燃料。而沼氣脫硫劑使用4—6個月后即達到飽和，失去脫硫功能，這時就需要將脫硫劑再生，再生后多使用12個就必須全部更換，否則，含有硫化氫氣體的沼氣做飯燃燒后，會發出刺鼻的二氧化硫氣體，那么大家知道沼氣廢脫硫劑一般怎么處理嗎？下面就由小編來為大家講解一下吧。

　　Biogas desulfurizer is a yellow brown granular substance installed in the desulfurizer bottle of a biogas purification regulator. Its function is to remove hydrogen sulfide gas from biogas, eliminate the odor of rotten eggs, and become a truly pollution-free energy-saving fuel. After 4-6 months of use, the biogas desulfurizer reaches saturation and loses its desulfurization function. At this time, the desulfurizer needs to be regenerated. If an additional 12 are used after regeneration, they must be replaced completely. Otherwise, the biogas containing hydrogen sulfide gas will emit pungent sulfur dioxide gas after cooking and burning. Do you know how to deal with biogas waste desulfurizer? Let me explain it to you below.

　　1、沼氣中的有害物質主要是硫化氫，它危害人體健康，對管道閥門及應用設備有較強的腐蝕作用，為減輕硫化氫對灶具及配套用具的腐蝕損害，延長設備使用壽命，保證人身體健康，必須安裝脫硫器。

　　1. The harmful substances in biogas are mainly hydrogen sulfide, which is harmful to human health and has a strong corrosive effect on pipeline valves and application equipment. In order to reduce the corrosion damage of hydrogen sulfide to stoves and supporting equipment, extend the service life of equipment, and ensure human health, it is necessary to install desulfurizers.

　　2、沼氣用戶使用的大多是集壓力表、脫硫器、開關為一體的“沼氣凈化調壓器”。一些農戶的凈化器在使用一段時間后，會莫名的發生局部類似于高溫燒壞的現象。這是因為這些農戶在出料或管道破裂時，灶具開關沒有關好，導致空氣進入凈化器后，與脫硫劑發生化學反應，產生高溫而燒壞的。有資料顯示，這一過程，可以產生300攝氏度的高溫。因此農戶在使用沼氣時，一定要注意：千萬不要讓空氣進入凈化器，避免發生意外。

　　2. Most biogas users use "biogas purification regulators" that integrate pressure gauges, desulfurizers, and switches. Some farmers' purifiers may inexplicably experience localized damage similar to high-temperature burning after a period of use. This is because these farmers did not turn off the stove switch properly when discharging or when the pipeline broke, causing the air to enter the purifier and react chemically with the desulfurizer, resulting in high temperatures and burning out. According to data, this process can generate a high temperature of 300 degrees Celsius. Therefore, when using biogas, farmers must be careful not to let air enter the purifier to avoid accidents.

　　脫硫劑

　　desulfurizer

　　3、脫硫劑在使用一段時間后，如果聞到有臭雞蛋的味道，說明脫硫劑已經失去脫硫效果，需要更換脫硫劑了。這個過程因使用頻率而有長短，一般建議半年至一年就要檢查一次。

　　3. After using the desulfurizer for a period of time, if you smell the smell of rotten eggs, it means that the desulfurizer has lost its desulfurization effect and needs to be replaced. This process varies in length depending on the frequency of use, and it is generally recommended to check it every six months to a year.

　　4、脫硫劑是可以再生的，再生方法很簡單，首先，關閉室外總開關和調控凈化器開關，打開凈化器將脫硫劑全部倒出放在陰涼、自然通風的水泥地面或鐵板上（嚴禁放在陽光下暴曬，嚴禁放在塑料制品、木板以及易燃物品上，避免燃燒引起火災），脫硫劑還原時間應在1天以上，待黑色變成橙、黃、褐色后，把脫硫劑顆粒重新裝回凈化器中，同時補足缺失的脫硫劑。

　　4. Desulfurizer can be regenerated, and the regeneration method is very simple. Firstly, turn off the outdoor main switch and control the purifier switch, turn on the purifier, pour out all the desulfurizer and place it on a cool, naturally ventilated cement floor or iron plate (strictly prohibited from being exposed to sunlight, plastic products, wooden boards, and flammable materials to avoid fire caused by combustion). The desulfurizer should be restored for more than 1 day. After the black color turns orange, yellow, or brown, the desulfurizer particles should be reinstalled in the purifier, and the missing desulfurizer should be replenished.

　　5、特別需要注意的是重新裝回凈化器內的只能是顆粒，不能將脫硫劑粉末裝回，以防粉末隨管道流入灶具噴嘴引起堵塞。一般來說，脫硫劑使用半年就要取出再生，再生一次后即要更換新的脫硫劑。急需使用的，也可以裝入新的脫硫劑，待換下的脫硫劑還原完畢，用塑料袋裝好封口，留至下一次更換使用。

　　5. It is particularly important to note that only particles can be reinstalled into the purifier, and desulfurizer powder cannot be reinstalled to prevent the powder from flowing into the stove nozzle through the pipeline and causing blockage. Generally speaking, the desulfurizer needs to be regenerated after six months of use, and a new desulfurizer needs to be replaced after one regeneration. For those in urgent need, they can also be filled with new desulfurizer. After the desulfurizer is reduced, it should be sealed in a plastic bag and kept for the next replacement.

　　以上就是小編為大家講解的關于沼氣廢脫硫劑一般怎么處理的全部內容，希望大家看過之后會有所了解，對于脫硫劑來說使用一段時間之后及時更換時正確使用沼氣的一項重要措施，神龍擁有高質量的優質產品和科學合理的環保達標排放整套解決方案和一站式的滿意服務，如有需要，歡迎致電咨詢。

　　The above is all the content that the editor has explained to you about how to deal with biogas waste desulfurizers in general. We hope that after reading it, you will have a better understanding. For desulfurizers, timely replacement after a period of use is an important measure to correctly use biogas. Shenlong has high-quality products, scientific and reasonable environmental standard emission solutions, and one-stop satisfactory services. If you need it, please feel free to call for consultation.

　　本文由  沼氣脫硫   友情奉獻.更多有關的知識請點擊  http://www.bjlidejia.com/   真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is contributed by the friendship of biogas desulfurization For more related knowledge, please click http://www.bjlidejia.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.